Windstar won't run (Full Version)

Ford Forums >> Past Ford Models >> Windstar/Aerostar

Windstar won't run

  

Gunfighter351 -> Windstar won't run (6/30/2007 4:32:25 AM)

My '98 Windstar 3.0L quit running on the way home from work. Had it towed. I listened for the sound of the fuel pump when I turned the key on and heard nothing. I was ready to replace the fuel pump but thought I ought to troubleshoot it a little further. Checked the fuses and found the PCM 30 amp mini fuse blown in the engine compartment fuse box. Replaced the fuse and started the engine.  Took it for a spin to see if it would blow again.  The further I drove the worse it ran, so I nursed it back home.  Checked the fuses and they're all good.  Is the fuel pump dying or is the OBD sending some bad info to the engine??  Any ideas? Thanks in advance.

  
Gunfighter351 -> RE: Windstar won't run (7/2/2007 3:47:31 AM)

Figured it out all by myself! The engine wiring harness was chaffed where it crosses from the front bank to the rear bank(behind the alternator) and was barely shorted to ground which caused the fuse to blow initially.  Noticed the battery was kinda low when I tried to start the engine.  I saw just the slightest waft of smoke coming from that area.  The wire that was actually chaffed was the power supply for the PCM coming from the engine compartment fuse panel. It was completely cut  but still touching the other half which gave the appearance (troubleshooting wise) that everything was okay.  Soldered the wire back together, heat shrinked and taped the crap out of it.  Ole Blue fired right up!

  

Page: [1]

Return to Ford Forum home page or view the Full Version of this page.